Water Fracturing with Continuous Sand for Horizontal Wells in the Pengshui Block

Liu Honglei; Han Qian; Li Ying; Lai Jianlin; Xu Qian

doi:10.11911/syztjs.201501003

Volume 43 Issue 1

Jan. 2015

Turn off MathJax

Article Contents

Abstract

References

Petroleum Drilling Techniques > 2015 > 43(1): 13-19. > DOI: 10.11911/syztjs.201501003

Liu Honglei, Han Qian, Li Ying, Lai Jianlin, Xu Qian. Water Fracturing with Continuous Sand for Horizontal Wells in the Pengshui Block[J]. Petroleum Drilling Techniques, 2015, 43(1): 13-19. DOI: 10.11911/syztjs.201501003

Citation:

PDF (8021 KB)

Water Fracturing with Continuous Sand for Horizontal Wells in the Pengshui Block

1.
Petroleum Engineering Technology Research Institute, Sinopec East China Company, Nanjing, Jiangsu, 210031, China;
2.
Shandong Victory Soft Co., Ltd., Dongying, Shandong, 257000, China

More Information

Received Date: May 25, 2014

Graphical Abstract

Abstract

Abstract

In order to improve recovery efficiency of normal temperature and low pressure shale gas reservoirs, the applicability of water fracturing technology with continuous sand for horizontal wells in the Pengshui Block was investigated.Base on preliminary fracture data from the same layers in offset wells, pressure prediction and fitting were made for Well Pengye 4HF in order to demonstrate the feasibility of water fracturing with sand.Calculation results showed that the operation pressure increased with the perforation depth in water fracturing in the Pengshui Block and it would not exceed the limit of 91 MPa as long as the perforation depth was no more than 4 340 m.According to the change of operation pressure, fracturing scheme of Well Pengye 4HF was adjusted and optimized in real-time, and tests were conducted to gradually reduce the concentration of resistance reducing agent until it was completely abandoned.In the last four sections of the well, water fracturing with continuous sand was performed, in which the maximum perforating depth was 2 434.0 m, the highest operation pressure was 69.2 MPa.cost fracturing fluid was reduced by about 4 million yuan.The results showed that operation pressure has a positive correlation with the perforation depth when conducting water fracturing with continuous sand.The application of the technology could greatly reduce the cost of fracturing fluid.

FullText(HTML)

References (15)

References

[1]	陈尚斌, 朱炎铭, 王红岩, 等.中国页岩气研究现状与发展趋势[J].石油学报, 2010, 31(4):689-694. Chen Shangbin, Zhu Yanming, Wang Hongyan, et al.Research status and trends of shale gas in China[J].Acta Petrolei Sinica, 2010, 31(4):689-694.
[2]	张艺耀, 王世彬, 郭建春.页岩地层压裂工艺新进展[J].断块油气田, 2013, 20(3):278-281. Zhang Yiyao, Wang Shibin, Guo Jianchun.New progress of hydraulic fracturing technology for shale formation[J].Fault-Block Oil Gas Field, 2013, 20(3):278-281.
[3]	王素兵.清水压裂工艺技术综述[J].天然气勘探与开发, 2005, 28(4):39-42. Wang Subing.Riverfrac treatment[J].Natural Gas Exploration and Development, 2005, 28(4):39-42.
[4]	才博, 史原鹏, 李拥军, 等.提高清水压裂人工裂缝导流能力新技术研究:以乌兰花凹陷兰5井为例[J].油气井测试, 2013, 22(4):10-12. Cai Bo, Shi Yuanpeng, Li Yongjun, et al.Study on improving water fracturing artificial fracture conductivity:taking Well Lan5 as an example in Wulanhua Depression[J].Well Testing, 2013, 22(4):10-12.
[5]	蒋廷学, 贾长贵, 王海涛, 等.页岩气网络压裂设计方法研究[J].石油钻探技术, 2011, 39(3):36-40. Jiang Tingxue, Jia Changgui, Wang Haitao, et al.Study on network fracturing design method in shale gas[J].Petroleum Drilling Techniques, 2011, 39(3):36-40.
[6]	Craig L Cipolla.Modeling production and evaluating fracture performance in unconventional gas reservoirs[R].SPE 118536, 2009.
[7]	吴顺林, 李宪文, 张矿生, 等.一种实现裂缝高导流能力的脉冲加砂压裂新方法[J].断块油气田, 2014, 21(1):110-113. Wu Shunlin, Li Xianwen, Zhang Kuangsheng, et al.A new method of pulse sand fracturing to achieve high conductivity of fracture[J].Fault-Block Oil Gas Field, 2014, 21(1):110-113.
[8]	李庆辉, 陈勉, Wang Fred P, 等.工程因素对页岩气产量的影响:以北美Haynesville页岩气藏为例[J].天然气工业, 2012, 32(4):1-6. Li Qinghui, Chen Mian, Wang Fred P, et al.Influences of engineering factors on shale gas productivity: a case study from the Haynesville shale gas reservoir in North America[J].Natural Gas Industry, 2012, 32(4):1-6.
[9]	李达, 贾建鹏, 滕飞启, 等.压裂施工过程中的井底压力计算[J].断块油气田, 2013, 20(3): 384-387. Li Da, Jia Jianpeng, Teng Feiqi, et al.Calculation of bottomhole pressure during fracturing[J].Fault-Block Oil Gas Field, 2013, 20(3):384-387.
[10]	赵金洲, 王松, 李勇明.页岩气藏压裂改造难点与技术关键[J].天然气工业, 2012, 32(4):46-49. Zhao Jinzhou, Wang Song, Li Yongming.Difficulties and techniques in the fracturing treatment of shale gas reservoirs[J].Natural Gas Industry, 2012, 32(4):46-49.
[11]	周成香, 周玉仓, 李双明, 等.川东南页岩气井压裂降压技术[J].石油钻探技术, 2014, 12(4):42-47. Zhou Chengxiang, Zhou Yucang, Li Shuangming, et al.Fracturing pressure reducing technique for shale gas well in the Southeastern Sichuan[J].Petroleum Drilling Techniques, 2014, 42(4):42-47.
[12]	贾长贵, 路保平, 蒋廷学, 等.DY2HF深层页岩气水平井分段压裂技术[J].石油钻探技术, 2014, 42(2):85-90. Jia Changgui, Lu Baoping, Jiang Tingxue, et al.Multi-stage horizontal well fracturing technology in deep shale gas Well DY2HF[J].Petroleum Drilling Techniques, 2014, 42(2):85-90.
[13]	蒋廷学, 卞晓冰, 袁凯, 等.页岩气水平井分段压裂优化设计新方法[J].石油钻探技术, 2014, 42(2):1-6. Jiang Tingxue, Bian Xiaobing, Yuan Kai, et al.A new method in staged fracturing design optimization for shale gas horizontal wells[J].Petroleum Drilling Techniques, 2014, 42(2):1-6.
[14]	刘红磊, 熊炜, 高应运, 等.方深1井页岩气藏特大型压裂技术[J].石油钻探技术, 2011, 39(3):46-52. Liu Honglei, Xiong Wei, Gao Yingyun, et al.Large scale fracturing technology of Fangshen 1 Shale Gas Well[J].Petroleum drilling techniques, 2011, 39(3):46-52.
[15]	周德华, 焦方正, 贾长贵, 等.JY1HF页岩气水平井大型分段压裂技术[J].石油钻探技术, 2014, 42(1):75-80. Zhou Dehua, Jiao Fangzheng, Jia Changgui, et al.Large-scale multi-stage hydraulic fracturing technology for shale gas horizontal Well JY1HF[J].Petroleum Drilling Techniques, 2014, 42(1):75-80.

[1]	LI Yang, CAO Xiaopeng, ZHAO Qingmin, LIU Zupeng, XUE Zhaojie, JIANG Long. Thoughts on Shale Oil Development in Continental Fault Basin in Jiyang Depression[J]. Petroleum Drilling Techniques, 2024, 52(4): 1-7. DOI: 10.11911/syztjs.2024056
[2]	ZHOU Bocheng, XIONG Wei, LAI Jianlin, FANG Qilong. Low-Cost Fracturing Technology in Normal-Pressure Shale Gas Reservoirs in Wulong Block[J]. Petroleum Drilling Techniques, 2022, 50(3): 80-85. DOI: 10.11911/syztjs.2022011
[3]	YUAN Guangjie, FU Li, WANG Yuan, GUO Kaijie, CHEN Gang. The Up-to-Date Drilling and Completion Technologies for Economic and Effective Development of Unconventional Oil & Gas and Suggestions for Further Improvements[J]. Petroleum Drilling Techniques, 2022, 50(1): 1-12. DOI: 10.11911/syztjs.2022002
[4]	YAN Lin, CHEN Fuli, WANG Zhiping, YAN Yiqun, CAO Jinjian, WANG Kunqi. Challenges and Technical Countermeasures for Effective Development of Shale Oil in China[J]. Petroleum Drilling Techniques, 2020, 48(3): 63-69. DOI: 10.11911/syztjs.2020058
[5]	CHEN Anming, LONG Zhiping, ZHOU Yucang, WANG Yanqi, PENG Xing, CAO Huaqing. Discussion on Low-Cost Drilling Technologies of Normal Pressure Shale Gas in the Outer Margin of the Sichuan Basin[J]. Petroleum Drilling Techniques, 2018, 46(6): 9-14. DOI: 10.11911/syztjs.2018127
[6]	WANG Minsheng, GUANG Xinjun, PI Guanglin, YAN Na, GENG Lidong. The Characteristics of Petroleum Engineering Technology Design and Innovation in a Low Oil Price Environment[J]. Petroleum Drilling Techniques, 2018, 46(6): 1-8. DOI: 10.11911/syztjs.2018133
[7]	Shen Jianzhong, Long Zhiping. Research and Application of Low Cost and Efficient CBM Drilling Technology in South Yanchuan[J]. Petroleum Drilling Techniques, 2015, 43(5): 69-74. DOI: 10.11911/syztjs.201505012
[8]	Liu Zhiliang, Zhi Dongming, Huang Hong, Nan Xin. Technique for Improving ROP and Benefit in Zhongguai Uplift Area of Xinjiang Oilfield[J]. Petroleum Drilling Techniques, 2015, 43(2): 14-18. DOI: 10.11911/syztjs.201502003
[9]	Ge Hongkui, Wang Xiaoqiong, Zhang Yi. A Technical Approach to Reduce Shale Gas Development Cost[J]. Petroleum Drilling Techniques, 2013, 41(6): 1-5. DOI: 10.3969/j.issn.1001-0890.2013.06.001
[10]	An Fengjun, Zhao Anjun, Zhou Huizhi, Duan Guifu. Effect Analysis of Secondary Sand Fracturing Using Four-Dimensional Seismic Imaging of Micro-Fractures[J]. Petroleum Drilling Techniques, 2013, 41(5): 98-101. DOI: 10.3969/j.issn.1001-0890.2013.05.019

Cited By

Cited by

Periodical cited type(19)

1.	马龙，杨森，罗立帆，刘桓竭. 考虑钻柱动力学的PDC钻头破岩动态特性. 机械设计与研究. 2025(01): 76-82 .
2.	黄明泉. 页岩气三维水平井剖面设计技术. 江汉石油职工大学学报. 2024(01): 45-47 .
3.	孙钢，姜政华，解赤栋. 隆页5-1HF一级井身结构攻关研究. 石化技术. 2024(03): 42-44 .
4.	王纪伟，宋丽阳，康玉柱，魏海鹏，陈刚，李东晖. 中美典型常压页岩气开发对比与启示. 特种油气藏. 2024(04): 1-9 .
5.	毕开原. 我国页岩气钻完井关键技术现状及发展趋势. 石油机械. 2024(11): 12-20+28 .
6.	施赵南，高斐. 力-化耦合作用下水化坍塌周期研究. 科技创新与应用. 2023(13): 71-74 .
7.	庄艳君. 安场页岩气井眼轨道优化与地质导向技术. 科技资讯. 2023(10): 131-136 .
8.	姚红生，王伟，何希鹏，郑永旺，倪振玉. 南川复杂构造带常压页岩气地质工程一体化开发实践. 油气藏评价与开发. 2023(05): 537-547 .
9.	姚红生，房启龙，袁明进，张壮. 渝东南常压页岩气工程工艺技术进展及下一步攻关方向. 石油实验地质. 2023(06): 1132-1142 .
10.	王运海，贺庆，朱智超，龙志平，彭兴，曹建山. 渝东南南川地区常压页岩气示范井应用评价及推广效果. 石油实验地质. 2023(06): 1160-1169 .
11.	蔡勋育，周德华，赵培荣，张华，钱恪然，万成祥. 中国石化深层、常压页岩气勘探开发进展与展望. 石油实验地质. 2023(06): 1039-1049 .
12.	张露，张玉胜，江波，王希勇，朱化蜀，张继尹. DY3-1HF常压页岩气水平井低成本钻井技术. 西部探矿工程. 2021(07): 89-91 .
13.	邓媛，何世明，邓祥华，彭远春，何世云，汤明. 力化耦合作用下的层理性页岩气水平井井壁失稳研究. 石油钻探技术. 2020(01): 26-33 . 本站查看
14.	夏海帮. 页岩气井双暂堵压裂技术研究与现场试验. 石油钻探技术. 2020(03): 90-96 . 本站查看
15.	耿朝辉. 我国页岩气钻井新技术及新工艺的研究与应用. 中国石油和化工标准与质量. 2019(07): 185-186 .
16.	孔令豪，何世明，汤明，袁兰峰，张光福. 考虑钻柱屈曲的环空压降计算. 断块油气田. 2019(03): 375-379 .
17.	赵景芳，刘雪婧，耿铁. BIO–OIL环保基液的研制与现场试验. 石油钻探技术. 2019(03): 75-81 . 本站查看
18.	朱亮，楼一珊，沈建中，贺庆，秦杜. 南川页岩气田岩石抗钻特性参数分布规律研究及应用. 油气藏评价与开发. 2019(05): 84-88 .
19.	蔡世荣，任克雄. 宜昌地区页岩气勘探开发前景及开发模式探析. 国土资源情报. 2019(09): 46-51 .

Other cited types(2)

Get Citation

PDF

XML

Article Metrics

Article views (4154) PDF downloads (4821) Cited by(21)

Water Fracturing with Continuous Sand for Horizontal Wells in the Pengshui Block

Abstract

References

Related Articles

Cited by

Periodical cited type(19)

Other cited types(2)

Catalog

Article Metrics

Related

Water Fracturing with Continuous Sand for Horizontal Wells in the Pengshui Block

Abstract

References

Related Articles

Cited by

Periodical cited type(19)

Other cited types(2)

Catalog

Article Metrics

Related

Export File

Citation

Format

Content