Establishment of Logging Evaluation Criteria for the Cementing Quality of Low-Density Cement Slurries

XIE Guanbao

doi:10.11911/syztjs.2022015

Volume 50 Issue 1

Mar. 2022

Turn off MathJax

Article Contents

Abstract

References

Petroleum Drilling Techniques > 2022 > 50(1): 119-126. > DOI: 10.11911/syztjs.2022015

XIE Guanbao. Establishment of Logging Evaluation Criteria for the Cementing Quality of Low-Density Cement Slurries[J]. Petroleum Drilling Techniques, 2022, 50(1): 119-126. DOI: 10.11911/syztjs.2022015

Citation:

PDF (2417 KB)

Establishment of Logging Evaluation Criteria for the Cementing Quality of Low-Density Cement Slurries

XIE Guanbao^{1, 2,}

1.
State Key Laboratory of Shale Oil and Gas Enrichment Mechanisms and Effective Development, Beijing, 102206, China
2.
Sinopec Research Institute of Petroleum Engineering, Beijing, 102206, China

More Information

Received Date: April 01, 2021
Revised Date: December 31, 2021
Available Online: February 17, 2022

Graphical Abstract

Abstract

Abstract

To provide a theoretical basis and criteria for the logging evaluation of the cementing quality of low-density cement slurries, the impacts of cement slurry density, cement sheath thickness, and cementing quality at the first interface on the conventional logging of cementing quality were analyzed according to the results of tests on acoustic characteristics at high temperatures and numerical simulation. The following understandings were obtained by the analysis: Affected by the outer diameter and thickness of casing, the difference in the relative amplitude of casing wave became increasingly obvious as the cement slurry density decreases. When there is a micro-annulus between the casing and the cement sheath, the amplitude increased monotonically with the the increase of cement sheath thickness and tended to be gentle when the cement sheath thickness was large. The micro-annulus significantly enhanced the amplitude of casing wave, especially for low-density cement slurry cementing. However, the effect of the cement slurry density weakened markedly after the thickness of the micro-annulus was increased to 5 mm. Depending on the analysis results, a log interpretation chart was established, and logging evaluation criteria were formulated for the cementing quality of low-density cement slurries. The evaluation criteria are expected to provide useful guidance for the logging evaluation of the cementing quality of low-density cement slurries in engineering practice.
- low density slurry,
- cementing quality,
- interpreting chart,
- evaluation criteria,
- acoustic variable density logging,
- cement bond logging

FullText(HTML)

References (15)

References

[1]	田鑫,章成广,毛志强. 低密度水泥固井质量评价方法研究[J]. 石油钻探技术,2006,34(6):36–38. doi: 10.3969/j.issn.1001-0890.2006.06.012 TIAN Xin, ZHANG Chengguang, MAO Zhiqiang. An evaluation method for cementing operations with light weight cement[J]. Petroleum Drilling Techniques, 2006, 34(6): 36–38. doi: 10.3969/j.issn.1001-0890.2006.06.012
[2]	步玉环,宋文宇,何英君,等. 低密度水泥浆固井质量评价方法探讨[J]. 石油钻探技术,2015,43(5):49–55. BU Yuhuan, SONG Wenyu, HE Yingjun, et al. Discussion of a method for evaluating cementing quality with low-density cement slurries[J]. Petroleum Drilling Techniques, 2015, 43(5): 49–55.
[3]	罗勇,宋文宇,步玉环,等. 低密度水泥固井质量评价方法的改进[J]. 天然气工业,2012,32(10):59–62. doi: 10.3787/j.issn.1000-0976.2012.10.014 LUO Yong, SONG Wenyu, BU Yuhuan, et al. Improvement on the cementing quality assessment method for light weight cement sheaths[J]. Natural Gas Industry, 2012, 32(10): 59–62. doi: 10.3787/j.issn.1000-0976.2012.10.014
[4]	武治强,许明标,刘书杰,等. 固井水泥环胶结质量检测与评价技术研究[J]. 重庆科技学院学报(自然科学版),2017,19(4):39–41. WU Zhiqiang, XU Mingbiao, LIU Shujie, et al. Study on testing method and evaluation technology of cement bond quality of well cementation[J]. Journal of Chongqing University of Science and Technology(Natural Sciences Edition), 2017, 19(4): 39–41.
[5]	王华,陶果,尚学峰,等. 轻质水泥固井质量声波测井评述与方法研究[J]. 测井技术,2014,38(2):165–173. WANG Hua, TAO Guo, SHANG Xuefeng, et al. Review and study on acoustic/ultrasonic methods for low-density cement bond logging[J]. Well Logging Technology, 2014, 38(2): 165–173.
[6]	刁小红. 特殊情况下的固井质量评价方法探讨[J]. 石油仪器,2012,26(5):59–61,65. DIAO Xiaohong. Cementing quality evaluation methods in some special cases[J]. Petroleum Instruments, 2012, 26(5): 59–61,65.
[7]	田进,许明标,鲜若琨,等. 川渝区块页岩气井固井质量评价方法应用现状[J]. 西部探矿工程,2021,33(4):47–49. doi: 10.3969/j.issn.1004-5716.2021.04.015 TIAN Jin, XU Mingbiao, XIAN Ruokun, et al. Application status of cementing quality evaluation methods for shale gas wells in Sichuan Chongqing Block[J]. West-China Exploration Engineering, 2021, 33(4): 47–49. doi: 10.3969/j.issn.1004-5716.2021.04.015
[8]	侯振永,郝晓良,马焕英,等. 超声固井质量评价方法改进及应用[J]. 测井技术,2019,43(6):657–660. HOU Zhenyong, HAO Xiaoliang, MA Huanying, et al. Improvement and application of the quality evaluation method for UIL cement bond[J]. Well Logging Technology, 2019, 43(6): 657–660.
[9]	唐军,章成广,张碧星,等. 基于声波–变密度测井的固井质量评价方法[J]. 石油勘探与开发,2016,43(3):469–475. TANG Jun, ZHANG Chengguang, ZHANG Bixing, et al. Cement bond quality evaluation based on acoustic variable density logging[J]. Petroleum Exploration and Development, 2016, 43(3): 469–475.
[10]	李维彦,王天雨,董红. IBC资料固井质量评价处理与分析[J]. 石油天然气学报,2014,36(6):79–82. doi: 10.3969/j.issn.1000-9752.2014.06.018 LI Weiyan, WANG Tianyu, DONG Hong. Evaluating cementing quality with IBC data[J]. Journal of Oil and Gas Technology, 2014, 36(6): 79–82. doi: 10.3969/j.issn.1000-9752.2014.06.018
[11]	杨旭辉,余厚全,陈强,等. 泄漏Lamb波在固井质量评价中的应用[J]. 应用声学,2017,36(3):241–248. doi: 10.11684/j.issn.1000-310X.2017.03.008 YANG Xuhui, YU Houquan, CHEN Qiang, et al. The application of leaky Lamb waves in cementing quality evaluation[J]. Journal of Applied Acoustics, 2017, 36(3): 241–248. doi: 10.11684/j.issn.1000-310X.2017.03.008
[12]	陈雷,杨红歧,肖京男,等. 杭锦旗区块漂珠–氮气超低密度泡沫水泥固井技术[J]. 石油钻探技术,2018,46(3):34–38. CHEN Lei, YANG Hongqi, XIAO Jingnan, et al. Ultra-low density hollow microspheres-nitrogen foamed cementing technology in Block Hangjinqi[J]. Petroleum Drilling Techniques, 2018, 46(3): 34–38.
[13]	惠伟,戴荣东,郝金克,等. 胜利油田固井质量评价测井技术现状及发展趋势[J]. 石油管材与仪器,2018,4(4):89–92. HUI Wei, DAI Rongdong, HAO Jinke, et al. Present status and development trend of cementing quality evaluation in Shengli Oilfield[J]. Petroleum Tubular Goods & Instruments, 2018, 4(4): 89–92.
[14]	张锦宏. 中国石化石油工程技术现状及发展建议[J]. 石油钻探技术,2019,47(3):9–17. doi: 10.11911/syztjs.2019061 ZHANG Jinhong. Current status and outlook for the development of Sinopec’s petroleum engineering technologies[J]. Petroleum Drilling Techniques, 2019, 47(3): 9–17. doi: 10.11911/syztjs.2019061
[15]	路保平. 中国石化石油工程技术新进展与发展建议[J]. 石油钻探技术,2021,49(1):1–10. doi: 10.11911/syztjs.2021001 LU Baoping. New progress and development proposals of Sinopec’s petroleum engineering technologies[J]. Petroleum Drilling Techni-ques, 2021, 49(1): 1–10. doi: 10.11911/syztjs.2021001

[1]	ZHAO Shaowei, YANG Jin, YANG Qiqi, CHEN Xuyue. Comprehensive Treatment Technology for Lost Circulation in Deep Exploration Wells of Bohai Oilfield[J]. Petroleum Drilling Techniques, 2025, 53(3): 84-89. DOI: 10.11911/syztjs.2025068
[2]	XU Kun, TAO Lin, LI Wenlong, LI Linbo, TANG Baisong, DI Yifeng, WANG Xu. Key Drilling Technologies for Metamorphic Buried Hill Reservoirs in Bohai Oilfield[J]. Petroleum Drilling Techniques, 2023, 51(3): 16-21. DOI: 10.11911/syztjs.2023070
[3]	SU Jian, DOU Peng, CUI Guojie, ZHU Guowei, ZHONG Sheng. Field Test of Fishbone Multi-Branch Hole Stimulation Technology in Bohai Oilfield[J]. Petroleum Drilling Techniques, 2022, 50(5): 102-107. DOI: 10.11911/syztjs.2022050
[4]	SUN Lin, LI Xuguang, HUANG Liping, XIA Guang, YANG Miao. Research and Application of Prolonged-Effect Acidizing Technology for Water Injection Wells in the Bohai Oilfield[J]. Petroleum Drilling Techniques, 2021, 49(2): 90-95. DOI: 10.11911/syztjs.2021029
[5]	GUO Hongfeng, YANG Shukun, DUAN Kaibin, JI Gongming, SHI Jingyan, AN Zonghui. An Improved Integrated Reverse Washing, Measuring and Adjusting Zonal Water Injection Process in the Bohai Oilfield[J]. Petroleum Drilling Techniques, 2020, 48(3): 97-101. DOI: 10.11911/syztjs.2020016
[6]	LIU Yigang, CHEN Zheng, MENG Xianghai, ZHANG Le, LAN Fei, SONG Xin. Cable Implanted Intelligent Injection Technology for Separate Injection Wells in Bohai Oilfield[J]. Petroleum Drilling Techniques, 2019, 47(3): 133-139. DOI: 10.11911/syztjs.2019044
[7]	YU Fahao, JIANG Zhaoping, BAI Jianhua, LIU Yigang, MENG Xianghai. Determination of the Temperature Resistance Capacity of Sand Control Screen Liner in Horizontal Heavy Oil Wells in the Bohai Oilfield[J]. Petroleum Drilling Techniques, 2018, 46(6): 65-70. DOI: 10.11911/syztjs.2018010
[8]	HOU Guanzhong, XI Jiangjun, HE Pengfei, BIAN Jie, XU Di. Research and Application of the Position-Occupying Drilling String Techniques for Twin Holes in Monobores in Bohai Oilfield[J]. Petroleum Drilling Techniques, 2016, 44(2): 70-75. DOI: 10.11911/syztjs.201602012
[9]	Liang Dan, Lü Xin, Jiang Shanshan, Liang Shoucheng, Feng Guozhi. The Technology of Classified Combination of Deep Profile Control in the Bohai Oilfield[J]. Petroleum Drilling Techniques, 2015, 43(2): 104-109. DOI: 10.11911/syztjs.201502018
[10]	Fu Jianmin, Han Xueyin, Ma Yingwen, Wang Jia, Ran Hongying. Application of PowerDrive VorteX Rotary Steering Drilling System in Bohai Bay[J]. Petroleum Drilling Techniques, 2014, 42(3): 118-122. DOI: 10.3969/j.issn.1001-0890.2014.03.022

Cited By

Cited by

Periodical cited type(7)

1.	张衍君，曾会，陶秀娟，张洋，周德胜. 致密储层体积压裂裂缝漏失及控制综述. 科学技术与工程. 2022(26): 11277-11286 .
2.	杨倩云，王宝田，杨华，刘学明. 形状记忆聚合物型温控膨胀堵漏剂的制备及应用. 钻井液与完井液. 2021(02): 189-195 .
3.	吴彦飞，张定军，杨斌，董莉，赵文锦，陈振斌. P(AA-AM)@SA@淀粉复合暂堵剂颗粒的制备及性能研究. 应用化工. 2019(03): 521-524 .
4.	田军，刘文堂，李旭东，刘云飞，郭建华. 快速滤失固结堵漏材料ZYSD的研制及应用. 石油钻探技术. 2018(01): 49-54 . 本站查看
5.	刘金华，刘四海，龙大清，陈曾伟，靳瑞环. 明1井交联成膜与化学固结承压堵漏技术. 石油钻探技术. 2017(02): 54-60 . 本站查看
6.	韩子轩，林永学，柴龙，李大奇. 裂缝性气藏封缝堵气技术研究. 钻井液与完井液. 2017(01): 16-22 .
7.	邱正松，刘均一，周宝义，暴丹，窦同伟，肖成才. 钻井液致密承压封堵裂缝机理与优化设计. 石油学报. 2016(S2): 137-143 .

Other cited types(5)

Get Citation

PDF

XML

Article Metrics

Article views PDF downloads Cited by(12)

Establishment of Logging Evaluation Criteria for the Cementing Quality of Low-Density Cement Slurries

Abstract

References

Related Articles

Cited by

Periodical cited type(7)

Other cited types(5)

Catalog

Article Metrics

Related

Establishment of Logging Evaluation Criteria for the Cementing Quality of Low-Density Cement Slurries

Abstract

References

Related Articles

Cited by

Periodical cited type(7)

Other cited types(5)

Catalog

Article Metrics

Related

Export File

Citation

Format

Content