抗高温聚合物降滤失剂PFL-L的研制与应用

杨小华, 钱晓琳, 王琳, 王显光, 董晓强

杨小华, 钱晓琳, 王琳, 王显光, 董晓强. 抗高温聚合物降滤失剂PFL-L的研制与应用[J]. 石油钻探技术, 2012, 40(6): 8-12. DOI: 10.3969/j.issn.1001-0890.2012.06.002
引用本文: 杨小华, 钱晓琳, 王琳, 王显光, 董晓强. 抗高温聚合物降滤失剂PFL-L的研制与应用[J]. 石油钻探技术, 2012, 40(6): 8-12. DOI: 10.3969/j.issn.1001-0890.2012.06.002
Yang Xiaohua, Qian Xiaolin, Wang Lin, Wang Xianguang, Dong Xiaoqiang. Development and Application of an High Temperature Resistant Polymer PFL-L as Fluid Loss Additive[J]. Petroleum Drilling Techniques, 2012, 40(6): 8-12. DOI: 10.3969/j.issn.1001-0890.2012.06.002
Citation: Yang Xiaohua, Qian Xiaolin, Wang Lin, Wang Xianguang, Dong Xiaoqiang. Development and Application of an High Temperature Resistant Polymer PFL-L as Fluid Loss Additive[J]. Petroleum Drilling Techniques, 2012, 40(6): 8-12. DOI: 10.3969/j.issn.1001-0890.2012.06.002

抗高温聚合物降滤失剂PFL-L的研制与应用

详细信息
    作者简介:

    杨小华(1969-),女,陕西礼泉人,1991年毕业于西北大学油田化学专业,高级工程师,主要从事钻井液处理剂开发及钻井液体系研究工作。联系方式(010)84988201,yangxh.sripe@sinopec.com。

  • 中图分类号: TE254+.4

Development and Application of an High Temperature Resistant Polymer PFL-L as Fluid Loss Additive

  • 摘要: 为使抗高温钻井液具有良好的流变性及高温高压滤失量,防止高温稠化,采用氧化-还原引发聚合反应,合成了一种低相对分子质量的抗高温聚合物降滤失剂PFL-L,进行了红外光谱和热重分析;采用凝胶渗透法测定了产物相对分子质量,评价了高温高盐情况下聚合物降滤失性能及配伍性。评价结果表明,PFL-L热稳定性好,产物分子量具有多分散性,适用于超深井钻井液处理剂,高温高盐条件下在显著降低钻井液滤失量的同时,可很好地控制钻井液高温下的黏度,抗温220℃,抗NaCl可达36%。该降滤失剂在徐闻X-3井进行了现场应用,应用结果证明,由PFL-L等处理剂形成的超高温钻井液热稳定性好,确保了徐闻X-3井三开长裸眼井段的顺利钻进,完钻井深6 010 m,取得了良好的应用效果,满足了安全高效钻井需求。
    Abstract: To prevent high temperature thickening and maintain good HTHP fluid loss and rheological property of high temperature resistant drilling fluids,a low molecular weight polymer fluid loss additive PFL-L was polymerized by oxidation/reduction reaction,and was analyzed by infrared spectrum and thermo gravimetric analysis.Its molecular weight was tested by gel permeation chromatography,the fluid loss and compatibility in drilling fluid were also evaluated under high temperature and high salinity.Test results show that PFL-L has good thermal stability and polydispersity of molecular weight,is suitable for drilling fluid in ultra-deep well as an additive.PFL-L can reduce fluid loss and control viscosity significantly at high temperature and high salinity,the heat resistance up to 220℃,salinity tolerance to saturation.It was applied in Well Xuwen X-3 which is an important exploratory well of Sinopec.Its field application shows that the drilling fluid has good high temperature stability,and met the demands of long open hole that drilled in the third spud to the total depth of 6 010 m.PFL-L,as an ultra-deep well drilling fluid filtrate reducer,it can also meet the demand of drilling safely efficiently in deep and ultra-deep wells.
  • [1]

    Udarbe R G,Hancock-Grossi K,George C R,et al.Method of and additive for controlling fluid loss from a drilling fluid:US,6107256.2000-08-22.

    [2]

    Hayes James R.High performance water-based mud system:US,7351680.2008-04-01.

    [3] 王中华.国内外超高温高密度钻井液技术现状与发展趋势[J].石油钻探技术,2011,39(2):1-7. Wang Zhonghua.Status and development trend of ultra-high temperature and high density drilling fluid at home and abroad[J].Petroleum Drilling Techniques,2011,39(2):1-7.
    [4] 杨小华,王中华.钻井液用高分子处理剂分子设计[J].精细与专用化学品,2010,18(1):14-18. Yang Xiaohua,Wang Zhonghua.Molecular design of polymer treatment agent used for drilling fluid[J].Fine and Specialty Chemicals,2010,18(1):14-18.
    [5] 王中华.超高温钻井液体系研究:抗高温钻井液处理剂设计思路[J].石油钻探技术,2009,37(3):1-7. Wang Zhonghua.Studies on ultra-high-temperature drilling fluid system:design ultra-high-temperature drilling fluid additives[J].Petroleum Drilling Techniques,2009,37(3):1-7.
    [6] 杨小华,李家芬,钱晓琳,等.超高温聚合物降滤失剂PFL-1的合成及性能评价[J].石油钻探技术,2010,38(2):37-42. Yang Xiaohua,Li Jiafen,Qian Xiaolin,et al.Synthesis and properties of an ultra-high-temperature polymer fluid loss additive PFL-1[J].Petroleum Drilling Techniques,2010,38(2):37-42.
    [7] 杨小华,王中华.乙烯基磺酸聚合物及钻井液体系的研究与应用[J].郑州大学学报:自然科学版,2001,33(2):89-91. Yang Xiaohua,Wang Zhonghua.Research and application of vinyl sulfonate copolymers and its drilling fluids[J].Journal of Zhengzhou University:Natural Science Edition,2001,33(2):89-91.
    [8] 王中华.钻井液用丙烯酰胺/2-丙烯酰胺基-2-甲基丙磺酸三元共聚物PAMS的合成[J].油田化学,2000,17(1):6-9. Wang Zhonghua.Synthesis of acrylamide/2-acrylamido-2-methyl propanesulfonic acid tercopolymer PAMS as filtrate reducer for drilling fluid[J].Oilfield Chemistry,2000,17(1):6-9.
    [9] 王中华.AMPS/AM/AN三元共聚物降滤失剂的合成与性能[J].油田化学,1995,12(4):367-369. Wang Zhonghua.Synthesis and propperties of AMPS/AM/AN terpolymer as filtrate loss controller for drilling fluids[J].Oilfield Chemistry,1995,12(4):367-369.
计量
  • 文章访问数:  3080
  • HTML全文浏览量:  73
  • PDF下载量:  3675
  • 被引次数: 0
出版历程
  • 收稿日期:  2012-01-08
  • 修回日期:  2012-09-24
  • 刊出日期:  1899-12-31

目录

    /

    返回文章
    返回